Smart wireless low power valve positioner dedicated for use in aviation laboratories
DOI: https://doi.org/10.3846/aviation.2025.23583Abstract
Testing aircraft components in laboratories is crucial phase of developing new technologies in aviation. Component testing helps to find design mistakes or check durability and efficiency, which increase safety. Despite such an important role of laboratory tests in Aviation, valve positioners with insufficient capabilities are often used during the research. In many cases range of tests are limited because too low flow or pressure control resolution. Moreover, valves with valve positioners are moved between test rigs and change placement in the test room which generate laborious work with wiring and configuration. This paper shows the way for increasing capabilities of laboratory control system with use of smart, wireless, battery powered valve positioners. Following sections show control algorithm, PCB design and test results. Research shows that designed valve positioner controller enables the system to reach control accuracy many times higher than typical valve positioners available on the market and could operate directly with external sensors. Moreover, low power design approach enables valve positioner to operate for months without battery replacement. In proposed approach, positioner could be controlled remotely through Bluetooth Low Energy and could work as a part of laboratory IoT (Internet of Things) network.
Keywords:
valve positioner, IoT, smart transducer, aviation, laboratory, component testingHow to Cite
Share
License
Copyright (c) 2025 The Author(s). Published by Vilnius Gediminas Technical University.
This work is licensed under a Creative Commons Attribution 4.0 International License.
References
Cheng, Q., Liu, Z., Jiang, A., Jiang, E., Xiao, Y., Li, F., & Jiang, J. (2020). Research on control algorithm of intelligent valve positioner based on parameter self-tuning. In 2020 39th Chinese Control Conference (CCC) (pp. 1380–1385). IEEE. https://doi.org/10.23919/CCC50068.2020.9188582
Dementyev, A., Hodges, S., Taylor, S., & Smith, J. (2013). Power consumption analysis of Bluetooth Low Energy, ZigBee and ANT sensor nodes in a cyclic sleep scenario. In 2013 IEEE International Wireless Symposium (IWS) (pp. 1–4). IEEE. https://doi.org/10.1109/IEEE-IWS.2013.6616827
Djadour, I., Aidel, S., & Medkour, H. (2019). Design and implementation of low power consumption wireless sensor node. Telekomnika, 17(6), 2729–2734. https://doi.org/10.12928/telkomnika.v17i6.12047
Emerson. (2023). Control valve handbook. https://www.emerson.com/documents/automation/control-valve-handbook-en-3661206.pdf
Fabry, S., Spodniak, M., Gasparovic, P., & Koscak, P. (2019). Aircraft gas turbine engine testing. Acta Avionica Journal, 21(2), 39–44. https://doi.org/10.35116/aa.2019.0016
Gu, L., Ge, X., Yao, X., & Jiang, B. (2012). Design of intelligent valve positioner. Applied Mechanics and Materials, 241–244, 552–556. https://doi.org/10.4028/www.scientific.net/AMM.241-244.552
He, Z., Xuan, H., & Bai, C. (2018). A blade release method for FBO test. Experimental Techniques, 42, 311–318. https://doi.org/10.1007/s40799-018-0233-6
Kabala, T., & Weremczuk, J. (2024). Smart wireless transducer dedicated for use in aviation laboratories. Sensors, 24(11), Article 3585. https://doi.org/10.3390/s24113585
Kalaiselvi, B. (2015). Design of smart positioner for a control valve to optimise backlash problem. Indian Journal of Science and Technology, 8(32). https://doi.org/10.17485/ijst/2015/v8i32/87454
Kambourakis, G., Kolias, C., Geneiatakis, D., Karopoulos, G., Makrakis, G. M., & Kounelis, I. (2020). A state-of-the-art review on the security of mainstream IoT wireless PAN protocol stacks. Symmetry, 12(4), Article 579. https://doi.org/10.3390/sym12040579
Kotha, V. (2023). Aircraft gas turbine engine test bed & module change workshop: Review for education & research. International Journal of Advanced Research in Engineering & Technology, 14(6), 29–48.
Li, S., Zhang, Y., & Hernes, M. (2019). Bluetooth low energy tree structure network (Report SWRA648). Texas Instruments. https://www.ti.com/lit/an/swra648/swra648.pdf
Łukasiewicz Research Network – Institute of Aviation. (2015). Aviation components and equipment test department. https://ilot.lukasiewicz.gov.pl/wp-content/uploads/2015/11/Aviation_components_and_equipment_test_department.pdf
Manikandan, L. P., Kulkarni, S. S., Radhakrishna, M., Jana, S., Gouda, G., Rajaram, N., Mahibalan, A., Kumar, A., & Kumar, V. A. (2018, January). Testing of main shaft bearing of typical aero engine. In Testing of Main Shaft Bearing of a Typical Aero Engine Conference (nPC-2013-Paper. No. 21010). ResearchGate.
Moreno-Cruz, F., Toral-López, V., Escobar-Molero, A., Ruíz, V. U., Rivadeneyra, A., & Morales, D. P. (2020). treNch: Ultra-low power wireless communication protocol for IoT and energy harvesting. Sensors, 20(21), Article 6156. https://doi.org/10.3390/s20216156
Nikolic, G., Stojcev, M., Stamenkovic, Z., Panic, G., & Petrovic, B. (2014). Wireless sensor node with low-power sensing. Electronics and Energetics, 27(3), 435–453. https://doi.org/10.2298/FUEE1403435N
Nordic Semiconductor. (2024). Software development kit documentation. https://www.nordicsemi.com/Products/Development-software/nRF-Connect-SDK
Nordic Semiconductor. (2019). nRF52840 Product Specification v1.1. https://docs.nordicsemi.com/bundle/ps_nrf52840/page/keyfeatures_html5.html
Pech, M., Vrchota, J., & Bednář, J. (2021). Predictive maintenance and intelligent sensors in smart factory: Review. Sensors, 21(4), Article 1470. https://doi.org/10.3390/s21041470
RTCA Inc. (2023). Environmental conditions and test procedures for airborne equipment (RTCA DO-160). https://do160.org/rtca-do-160g/
SAE International. (2016). Guidelines for engine component tests. aerospace recommended practice (ARP5757A). https://www.sae.org/standards/content/arp5757a/
Schütze, A., Helwig, N., & Schneider, T. (2018). Sensors 4.0 – Smart sensors and measurement technology enable Industry 4.0. Journal of Sensors and Sensor Systems, 7(1), 359–371. https://doi.org/10.5194/jsss-7-359-2018
Sharma, A., Sharma, S., & Gupta, D. (2021). A review of sensors and their application in Internet of Things (IOT). International Journal of Computer Applications, 174(24), 27–34. https://doi.org/10.5120/ijca2021921148
Texas Instruments. (2019). DRV8874 Datasheet.
Ullo, S. L., & Sinha, G. R. (2021). Advances in IoT and smart sensors for remote sensing and agriculture applications. Remote Sensing, 13(13), Article 2585. https://doi.org/10.3390/rs13132585
U.S. Department of Transportation. (2010). Engine System and Component Tests (33.91-1). U.S. Department of Transportation.https://www.faa.gov/documentLibrary/media/Advisory_Circular/AC-33.91-1.pdf
Woolley, M. (2020). Bluetooth core specification version 5.2 feature overview. https://www.bluetooth.com/wp-content/uploads/2020/01/Bluetooth_5.2_Feature_Overview.pdf
Xu, W., Xiao, C., & Huang, M. (2019). Research on control system of intelligent valve positioner (pp. 653–656). In 2nd World Conference on Mechanical Engineering and Intelligent Manufacturing (WCMEIM). IEEE. https://doi.org/10.1109/WCMEIM48965.2019.00138
Xu, H., & Zhang, L. (2021). A software and hardware design scheme of intelligent valve positioner. E3S Web of Conferences, 268, Article 01067. https://doi.org/10.1051/e3sconf/202126801067
Yang, J., & Li, X. (2010). Design and implementation of low-power wireless sensor networks for environmental monitoring. In 2010 IEEE International Conference on Wireless Communications, Networking and Information Security (pp. 593–597). IEEE. https://doi.org/10.1109/WCINS.2010.5543952
Zhang, B., Jiang, A., Jiang, J., Qi, Y., Xue, L., & Wang, Y. (2022). A new positioning strategy based on parameter tuning and optimal control technique for pneumatic control valve. Actuators, 11(10), Article 279. https://doi.org/10.3390/act11100279
View article in other formats
CrossMark check
Published
Issue
Section
Copyright
Copyright (c) 2025 The Author(s). Published by Vilnius Gediminas Technical University.
License
This work is licensed under a Creative Commons Attribution 4.0 International License.